? 2016 littelfuse, inc. specifcations are subject to change without notice. revised: 09/10/16 agency agency file number e230531 tvs devices are ideal for the protection of i/o interfaces, v cc bus and other vulnerable circuits used in telecom, computer, industrial and consumer electronic applications. applications features the 15kpa-hr high reliability series is designed specifcally to protect sensitive electronic equipment from voltage transients induced by lightning and other transient voltage events. descriptios maximum ratings and thermal characteristics (t a =25 o c unless otherwise noted) agency approvals 15kpa-hr series functional diagram bi-directional uni-directional cathode anode bi-directional uni-directional r ohs pb e3 parameter symbol value unit peak pulse power dissipation by 10/1000s test waveform (fig.2) (note 1) p ppm 15000 w steady state power dissipation on infnite heat sink at t l =75oc (fig. 6) p d 8.0 w peak forward surge current, 8.3ms single half sine wave unidirectional only (note 2) i fsm 400 a operating junction and storage temperature range t j , t stg -55 to 175 c typical thermal resistance junction to lead r ujl 8.0 c/w typical thermal resistance junction to ambient r uja 40 c/w notes: 1. non-repetitive current pulse , per fig. 4 and derated above t j (initial) =25 o c per fig. 3. 2. measured on 8.3ms single half sine wave or equivalent square wave, duty cycle=4 per minute maximum. ? 15000w peak pulse capability at 10/1000s waveform, repetition rate (duty cycles):0.01% ? glass passivated chip junction in p600 package ? fast response time: typically less than 1.0ps from 0 volts to bv min ? excellent clamping capability ? typical failure mode is short from over-specifed voltage or current ? whisker test is conducted based on jedec jesd201a per its table 4a and 4c ? iec-61000-4-2 esd 30kv(air), 30kv (contact) ? esd protection of data lines in accordance with iec 61000-4-2 ? eft protection of data lines in accordance with iec 61000-4-4 ? low incremental surge resistance ? typical i r less than 2a when v br min>36v ? high temperature soldering guaranteed: 260c/10 seconds / 0.375, (9.5mm) lead length, 5 lbs., (2.3kg) tension ? v br @ t j = v br @25c x (1+ t x (t j - 25)) ( t:temperature coeffcient, typical value is 0.1%) ? plastic package is fammability rated v-0 per underwriters laboratories ? lead-free matte tin plated package ? halogen free and rohs compliant ? pb-free e3 means 2nd level interconnect is pb- free and the terminal fnish material is tin(sn) (ipc/ jedec j-std-609a.01) tvs diodes axial leaded C 15000w > 15kpa-hr series
? 2016 littelfuse, inc. specifcations are subject to change without notice. revised: 09/10/16 electrical characteristics (t a =25c unless otherwise noted) part number (uni) part number (bi) reverse stand off voltage v r (volts) breakdown voltage v br (volts) @ i t test current i t (ma) maximum peak pulse current i pp (a) maximum reverse leakage i r @ v r ( a) maximum clamping voltage v c @ i pp (v) agency approval min max 15kpa17a -hr 15kpa17ca-hr 17 18.99 20.79 50 515.4 5000 29.3 x 15kpa18a-hr 15kpa18ca-hr 18 20.11 22.01 50 488.7 5000 30.9 x 15kpa20a-hr 15kpa20ca-hr 20 22.34 24.46 20 440.2 1500 34.3 x 15kpa22a-hr 15kpa22ca-hr 22 24.57 26.91 10 407.0 500 37.1 x 15kpa24a-hr 15kpa24ca-hr 24 26.81 29.35 5 371.0 150 40.7 x 15kpa26a-hr 15kpa26ca-hr 26 29.04 31.80 5 343.2 50 44.0 x 15kpa28a-hr 15kpa28ca-hr 28 31.28 34.24 5 317.9 25 47.5 x 15kpa30a-hr 15kpa30ca-hr 30 33.51 36.7 5 297.8 15 50.7 x 15kpa33a-hr 15kpa33ca-hr 33 36.9 40.4 5 276.1 2 54.7 x 15kpa36a-hr 15kpa36ca-hr 36 40.2 44.0 5 252.5 2 59.8 x 15kpa40a-hr 15kpa40ca-hr 40 44.7 48.9 5 229.5 2 65.8 x 15kpa43a-hr 15kpa43ca-hr 43 48.0 52.6 5 216.3 2 69.8 x 15kpa45a-hr 15kpa45ca-hr 45 50.3 55.0 5 207.4 2 72.8 x 15kpa48a-hr 15kpa48ca-hr 48 53.6 58.7 5 194.3 2 77.7 x 15kpa51a-hr 15kpa51ca-hr 51 57.0 62.4 5 182.1 2 82.9 x 15kpa54a-hr 15kpa54ca-hr 54 60.3 66.0 5 172.2 2 87.7 x 15kpa58a-hr 15kpa58ca-hr 58 64.8 70.9 5 161.0 2 93.8 x 15kpa60a-hr 15kpa60ca-hr 60 67.0 73.4 5 155.0 2 97.4 x 15kpa64a-hr 15kpa64ca-hr 64 71.5 78.3 5 144.9 2 104.2 x 15kpa70a-hr 15kpa70ca-hr 70 78.2 85.6 5 132.9 2 113.6 x 15kpa75a-hr 15kpa75ca-hr 75 83.8 91.7 5 123.8 2 122.0 x 15kpa78a-hr 15kpa78ca-hr 78 87.1 95.4 5 119.7 2 126.1 x 15kpa85a-hr 15kpa85ca-hr 85 94.9 104.0 5 109.7 2 137.6 x 15kpa90a-hr 15kpa90ca-hr 90 100.5 110.1 5 103.7 2 145.6 x 15kpa100a-hr 15kpa100ca-hr 100 111. 7 122.3 5 93.6 2 161.3 x 15kpa110a-hr 15kpa110ca-hr 110 122.9 134.5 5 84.5 2 178.6 x 15KPA120A-HR 15kpa120ca-hr 120 134.0 146.8 5 78.5 2 192.3 x 15kpa130a-hr 15kpa130ca-hr 130 145.2 159.0 5 72.5 2 208.3 x 15kpa150a-hr 15kpa150ca-hr 150 167.6 183.5 5 62.4 2 241.9 x 15kpa160a-hr 15kpa160ca-hr 160 178.7 195.7 5 58.4 2 258.6 x 15kpa170a-hr 15kpa170ca-hr 170 189.9 207.9 5 55.4 2 272.7 x 15kpa180a-hr 15kpa180ca-hr 180 201.1 220.1 5 52.3 2 288.5 x 15kpa200a-hr 15kpa200ca-hr 200 223.4 244.6 5 47.3 2 319.1 x 15kpa220a-hr 15kpa220ca-hr 220 245.7 269.1 5 42.4 2 356.0 x 15kpa240a-hr 15kpa240ca-hr 240 268.1 293.5 5 39.3 2 384.6 x 15kpa260a-hr 15kpa260ca-hr 260 290.4 318.0 5 36.2 2 416.7 x 15kpa280a-hr 15kpa280ca-hr 280 312.8 342.4 5 33.2 2 454.5 x note: 1. for bidirectional type having v r of 30 volts and less, the i r limit is double. 2. each lot of parts will pass group b test requirement. tvs diodes axial leaded C 15000w > 15kpa-hr series
? 2016 littelfuse, inc. specifcations are subject to change without notice. revised: 09/10/16 i-v curve characteristics vc v br v r i r i t i pp v uni-directional v f vc v br v r i r i t i pp v vc v br v r i pp i r i t bi-directional p ppm peak pulse power dissipation -- max power dissipation v r stand-off voltage -- maximum voltage that can be applied to the tvs without operation v br breakdown voltage -- maximum voltage that fows though the tvs at a specifed test current (i t ) v c clamping voltage -- peak voltage measured across the tvs at a specifed ippm (peak impulse current) i r reverse leakage current -- current measured at v r v f forward voltage drop for uni-directional group b test requirement screen method condition requirement surge test 10/1000 s peak pluse waveform maximum clamping voltage (v c ) @ peak plus current (i pp ) sample size 45 perform 10x accept 0 failures burn - in (htrb) mil -std-750, method 1038.5 applied voltage 100% v r @150 c sample size 45 340 hours (680 hours for bi- direction products, each direction 340 hours) accept 0 failures electrical test -- i r @v r , v( br )@i t sample size 45 accept 0 failures screen process 100% vision inspection mil-std-750 method 2074 100% high temperature storage life (168hrs,175 c ) mil-std-750 method 1031 100% temperature cycle test (-55 to150 c , 20 cycles, dwell time 15 min) mil-std-750 method 1051 100% surge test (2x) mil-std-750 method 4066 100% htrb 150 c bias=vr(80% breakdown voltage, 96hrs, and each direction at 96 hrs for bi-directional products) mil-stdC750 method 1038 final electrical test( 100% 3 sigma limit, 100% dynamic test and pat limit) mil-std-750 method 4016.4021.4011 note: up-screen program can be specifed by customers request via contacting littelfuse service tvs diodes axial leaded C 15000w > 15kpa-hr series
? 2016 littelfuse, inc. specifcations are subject to change without notice. revised: 09/10/16 vo lt age tr an si en ts ti me vo lt age acro ss tv s current through tv s voltage or current figure 1 - tvs transients clamping waveform ratings and characteristic curves (t a =25c unless otherwise noted) figure 2 - peak pulse power rating curve 1 10 10 0 100 0 t d -pulse width (ms.) p ppm -peak pulse power (kw ) 0. 0010 .0 10 .1 11 0 t j initial = t amb i ppm - p eak p ulse cur rent, % i rsm 0 0 50 10 0 15 0 1. 0 2.0 3.0 4.0 t r =1 0sec p eak v alue i ppm i ppm 2 t j =25c p ulse width(td) is de?ned as the point where the peak cur rent decays to 50% of i ppm 1 0/1 000sec. w aveform as de?ned by r.e. a t d t-t ime (ms) half v alue i ppm ( ) figure 3 - peak pulse power derating curve figure 4 - test pulse waveform cj (p f) v br - reverse breakdown vo ltage (v) 1 10 100 100 0 10000 100000 0 50 1001 50 2002 50 3003 50 uni- di rec on al v = v r uni- di rec on al v =0 v bi-d ir ec o na l v= 0v bi-d ir ec o na l v= v r figure 5 - typical junction capacitance tr an si en t th er ma l im pe da nc e ( c/ w) -p ul se du ra ti on (s ) t p 0. 1 1 10 100 0. 01 0. 11 10 100 100 0 figure 6 - typical transient thermal impedance peak pulse power (p pp ) or current (i pp ) derating in percentage % 0 25 50 75 100 02 55 07 5 100 125 150 175 200 t j - initial junction temperature (oc) tvs diodes axial leaded C 15000w > 15kpa-hr series
? 2016 littelfuse, inc. specifcations are subject to change without notice. revised: 09/10/16 physical specifcations weight 0.07oz., 2.5g case p600 molded plastic body over passivated junction. polarity color band denotes the cathode except bipolar. terminal matte tin axial leads, solderable per jesd22-b102. environmental specifcations high temp. storage jesd22-a103 htrb jesd22-a108 temperature cycling jesd22-a104 h3trb jesd22-a101 rsh jesd22-b106 i fs m - pe ak fo rw ar d su rv e curre nt (a ) nu mb er of cy cles at 60 hz 0 100 200 300 400 500 600 700 800 900 1000 11 0 100 figure 7 - maximum non-repetitive peak forward surge current uni-directional only i f -p ea k fo rw ar d cu rre nt (a ) v f -p ea k fo rw ar d vo lt ag e( v) 0. 1 1 10 100 0. 02 .0 4. 06 .0 8. 01 0. 0 12. 0 3 st ac ke d-di e 2 st ac ke d-di e figure 8 - peak forward voltage drop vs peak forward current (typical values) dimensions dimensions inches millimeters min max min max a 1.000 - 25.40 - b 0.340 0.360 8.60 9.10 c 0.048 0.052 1.22 1.32 d 0.340 0.360 8.60 9.10 p600 d a a c b cathode band (for uni-directional products only) packing options part number component package quantity packaging option packaging specifcation 15kpa xxxxx-hr p600 800 tape & reel eia std rs-296 tvs diodes axial leaded C 15000w > 15kpa-hr series
? 2016 littelfuse, inc. specifcations are subject to change without notice. revised: 09/10/16 part numbering system t ype code: a uni-directional (5% v br v olt age t olerance) ca bi-directional (5% v br v olt age t olerance) series code 15kp a xxx xx v r vo lta ge high reliabilit y -hr part marking system f 15kp a xxx -hr yy ww trace code marking yy:year code ww: week code product type littelfuse logo cathode band (for uni-directional products only) tape and reel specifcation 2.063+0.079/-0.039 2.56 0.394+/-0.020 2.75 0.047 (330.2) r ecess depth max. 0.75 (1 9.05) of f center either side 0.028(0.7) dimensions are in inc hes/mm 0.236 (65.0) (1 0.0+/-0.5) (53.0+2.0/-1 .0) (6.0) (1 .2) (69.85) 1 3.0 (7 6.2) 3.0 0.68 (1 7. 27) direction of feed rtca/do-160g wave 4 and wave 5 tvs diodes axial leaded C 15000w > 15kpa-hr series
? 2016 littelfuse, inc. specifcations are subject to change without notice. revised: 09/10/16 part number (uni) part number (bi) 25c 70c 120c wave 4 (6.4/69us) wave 5a (40/120us) wave 4 (6.4/69us) wave 5a (40/120us) wave 4 (6.4/69us) wave 5a (40/120us) l3 l4 l5 l3 l4 l3 l4 l5 l3 l4 l3 l4 l5 l3 l4 60a 150a 320a 300a 750a 60a 150a 320a 300a 750a 60a 150a 320a 300a 750a 15kpa17a -hr 15kpa17ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass pass 15kpa18a-hr 15kpa18ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass pass 15kpa20a-hr 15kpa20ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass pass 15kpa22a-hr 15kpa22ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass pass 15kpa24a-hr 15kpa24ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass - 15kpa26a-hr 15kpa26ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass - 15kpa28a-hr 15kpa28ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass - 15kpa30a-hr 15kpa30ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass - 15kpa33a-hr 15kpa33ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass - 15kpa36a-hr 15kpa36ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass - 15kpa40a-hr 15kpa40ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass - 15kpa43a-hr 15kpa43ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass - 15kpa45a-hr 15kpa45ca-hr pass pass pass pass pass pass pass pass pass pass pass pass pass pass - 15kpa48a-hr 15kpa48ca-hr pass pass pass pass - pass pass pass pass - pass pass pass pass - 15kpa51a-hr 15kpa51ca-hr pass pass pass pass - pass pass pass pass - pass pass pass pass - 15kpa54a-hr 15kpa54ca-hr pass pass pass pass - pass pass pass pass - pass pass pass pass - 15kpa58a-hr 15kpa58ca-hr pass pass pass pass - pass pass pass pass - pass pass pass - - 15kpa60a-hr 15kpa60ca-hr pass pass pass pass - pass pass pass - - pass pass pass - - 15kpa64a-hr 15kpa64ca-hr pass pass pass pass - pass pass pass - - pass pass pass - - 15kpa70a-hr 15kpa70ca-hr pass pass pass pass - pass pass pass - - pass pass pass - - 15kpa75a-hr 15kpa75ca-hr pass pass pass pass - pass pass pass - - pass pass pass - - 15kpa78a-hr 15kpa78ca-hr pass pass pass pass - pass pass pass - - pass pass pass - - 15kpa85a-hr 15kpa85ca-hr pass pass pass pass - pass pass pass - - pass pass pass - - 15kpa90a-hr 15kpa90ca-hr pass pass pass pass - pass pass pass - - pass pass pass - - 15kpa100a-hr 15kpa100ca-hr pass pass pass - - pass pass pass - - pass pass pass - - 15kpa110a-hr 15kpa110ca-hr pass pass pass - - pass pass pass - - pass pass pass - - 15KPA120A-HR 15kpa120ca-hr pass pass pass - - pass pass pass - - pass pass pass - - 15kpa130a-hr 15kpa130ca-hr pass pass pass - - pass pass pass - - pass pass - - - 15kpa150a-hr 15kpa150ca-hr pass pass pass - - pass pass pass - - pass pass - - - 15kpa160a-hr 15kpa160ca-hr pass pass pass - - pass pass - - - pass pass - - - 15kpa170a-hr 15kpa170ca-hr pass pass pass - - pass pass - - - pass pass - - - 15kpa180a-hr 15kpa180ca-hr pass pass pass - - pass pass - - - pass - - - - 15kpa200a-hr 15kpa200ca-hr pass pass pass - - pass pass - - - pass - - - - 15kpa220a-hr 15kpa220ca-hr pass pass pass - - pass - - - - pass - - - - 15kpa240a-hr 15kpa240ca-hr pass pass pass - - pass - - - - pass - - - - 15kpa260a-hr 15kpa260ca-hr pass pass - - - pass - - - - pass - - - - 15kpa280a-hr 15kpa280ca-hr pass pass - - - pass - - - - pass - - - - pin injection protection per rtca/do-160g note: 1. l1 = level1, l2 = level 2, l3 = level 3, l4 = level 4, l5 = level 5 tvs diodes axial leaded C 15000w > 15kpa-hr series
|
